Product ID:ACTIVATOR, PART B, MIL-C-22750E, GREY 36374
MSDS Date:03/23/1992
FSC:8010
NIIN:01-316-3038
Kit Part:Y
MSDS Number: BNPYT

CRAWFORD LABORATORIES, INC.

4165 SOUTH EMERALD AVENUE
CHICAGO, IL 60609
US

Emergency Phone: 800-424-9300 CHEMTREC

Info Phone: 312-376-7132

Preparer: DAVID SCHMETTERER

Cage: DO165

CRAWFORD LABORATORIES, INC

CHICAGO, IL 60609 US

Telephone: 312-376-7132

Cage: 5V430

NONYLPHENOL (VAPOR PRESSURE 0.9 MM HG) (CONTAINS A TRACE OF

CAS: 25154-52-3

RTECS: SM5600000

Fraction By Weight: 15%

META XYLENE DIAMINE

CAS: 1477-55-0

RTECS: PF8970000

Fraction By Weight: 10%

ACGIH TLV: .1 MG/M3

AMINE ADDUCT

CAS: 68738-77-2

Fraction By Weight: <5%

METHYL ETHYL KETONE (SARA III) ((VAPOR PRESSURE 71.2 MM HG)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 40%

OSHA PEL 100 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CRYSTALLINE SILICA

CAS: 14464-46-1

RTECS: VV7325000

Fraction By Weight: 15%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.05 MG/M3 RDUST9293

0-10% AMORPHOUS SILICA, CAS

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 15%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

468 GPL

RTECS: 9999999VO

Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:OVEREXPOSURE: ACUTE TOXICITY. SEVERE
EYE IRRITATION, POSSIBLY RESULTING IN PERMANENT DAMAGE. IRRITATED
MUCOUS MEMBRANES. VOMITING DUE TO INGESTION. DEFATTING AND DRYING
OF THE SKIN. SENSITIZATION AFTE R REPEATED CONTACT.
Explanation of Carcinogenicity:IARC HAS DETERMINED THAT THERE IS
LIMITED EVIDENCE OF THE CARCINOGENICITY OF CRYSTALLINE SILICA TO
HUMANS.
Effects of Overexposure:EFFECTS OF ACUTE TOXICITY: HEADACHE, DIZZINESS,
NAUSEA, AND LOSS OF CONSCIOUSNESS.

First Aid:EYE: FLUSH W/LUKEWARM LOW PRESSURE WATER 15 MIN, LIFTING
EYELIDS. GET MED AID. INHALATION: REMOVE TO FRESH AIR & PROVIDE
OXYGEN IF BREATHING IS DIFFICULT. GIVE ARTIFICIAL RESPIRATION IF
NOT BREATHING. GET MED AID. KEEP WARM & COMFORTABLE. INGESTION:
CALL DR IMMEDIATLEY. INDUCE VOMITING ON DR'S INSTRUCTIONS. IF
VOMITING OCCURS, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQ
INTO LUNGS. NEVER *

Flash Point Method:SCC
Flash Point:22.0F,-5.6C
Lower Limits:2
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL.
Fire Fighting Procedures:USE WATER TO KEEP EXPOSED CONTAINERS COOL, &
TO KEEP FLAMMABLE STRUCTURES WET. DON'T ENTER FIRE AREA W/OUT
PROTECTION BECAUSE HZD DECOMP PRODUCT MAY BE PRESENT.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.

Spill Release Procedures:WARNING--FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITH AN ABSORBENT & PLACE IN NON-LEAKING CONTAINERS. SEAL
TIGHTLY FOR PROPER DISPOS AL.

Handling and Storage Precautions:TREAT AS HAZARDOUS-FLAMMABLE MATERIAL.
KNOW DOT REGULATIONS BEFORE ATTEMPTING TO TRANSPORT THIS MATERIAL.
WARNING: HOT ORGANIC CHEMICAL VAPOR/MIST **
Other Precautions:** SUSCEPTIBLE TO SUDDEN SPONTANEOUS COMBUSTION WHEN
MIXED W/AIR. IGNITION MAY OCCUR AT TEMPS BELOW AUTOIGNITION.
IGNITION TEMPS DECREASE W/INCREASING VAPOR VOLUME & VAPOR/AIR
CONTACT TIME & ARE INFLU ENCED BY PRESSURE CHANGES. ***

Respiratory Protection:IMPORTANT-MUST PROVIDE ADEQUATE VENT TO MAINTAIN
VAPOR CONCENTRATIONS BELOW THE ESTABLISHED TLV. IN MORE CONFINED
AREAS A NIOSH/MSHA APPROVED RESPIRATOR EQUIPPED WITH ORGANIC VAPOR
CARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION. SEE RESPIRATORY
PROTECTION.
Protective Gloves:USE RUBBER GLOVES.
Eye Protection:WEAR SAFETY GOGGLES &/OR FACE SHIELD
Other Protective Equipment:HAVE EYE BATH & SAFETY SHOWER AVAILABLE.
*GIVE UNCONSCIOUS PERSON LIQS. SKIN: FLUSH W/WATER
WHILE****
Work Hygienic Practices:N/K****REMOVING CONTAM CLOTH/SHOES. WASH W/SOAP
& WATER. DON'T REUSE CONTAM CLOTH/SHOES. IF IRRIT PERSISTS, GET MED
AID.
Supplemental Safety and Health
***IGNIT MAY OCCUR AT TYPICAL ELEVATED TEMP PROCESS CONDITIONS,
ESPECIALLY IN PROCESS OPERATING UNDER VACUUM IF SUBJECTED TO SUDDEN
INGRESS OF AIR, OR OUTSIDE PROCESS EQUIP OPERATING UNDER ELEVATED
PR ESSURE IF SUDDEN ESCAPE OF VAPORS/MISTSTO ATM OCCURS. EVALUATE
ANY PROPOSED USE OF PROD IN ELEVATED TEMP PROCESSES.

HCC:F5
Boiling Pt:B.P. Text:174 TO 567F
Vapor Density:> AIR
Spec Gravity:1.16
Viscosity:>200 CS
Evaporation Rate & Reference:4.63 X N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:GRAY LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:58.3
Corrosion Rate:NOT CORR

Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES, AND
INCOMPATIBILITIES.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. CONTACT AN APPROVED DISPOSAL FACILITY. EPA
HAZARDOUS WASTE CODES D001. IGNITABLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.